Choose a section…
Title Page (p.1)
Using the manual (p.2)
Factory Type symbols (p.8)
General characteristics (p.10)
Grnd clearance, weight (p.11)
Tyres/rims, dimensions (p.10)
Advice and precautions (p.13)
Electrical precautions (p.13)
LHS2 (p.15)
LHM (p.16)
Hydraulic work - general (p.17)
Draining the fluid (p.21)
Refilling (p.22)
Approved pastes, glues, solvents (p.25)
Engine (p.27)
Data (p.27)
Oil circulation diagram (p.28)
Cross-section drawings (p.29)
Data (IE) (p.36)
Cross-section (IE) (p.37)
Oil circulation (IE) diagram (p.39)
Adjusting valve clearances (p.40)
Adjusting IE valve clearances (p.42)
Adjusting engine mountings (p.44)
Weber carburettor (p.46)
Setting clutch clearance and idle (bvh) (p.51)
Adjusting idle speed (bvm) (p.53)
Adjusting accelerator control (p.54)
Adjusting idle (post Sep '72 (p.55)
Adjusting idle (BW) (p.56)
Adjusting EFI (bvh) (p.57)
Adjusting EFI (bvm) (p.60)
Adjusting EFI (bw) (p.61)
Using Citroen tester (p.62)
Using Bosch tester (p.90)
Fuel pump -EFI (p.116)
Fuel pump - carburettor (p.117)
Ignition (p.119)
Ignition advance curves (p.119)
Set static timing to '71 (p.124)
Set static timing '71-> (p.125)
Set timing w. strobe (p.127)
Test-bench distributor check (p.133)
Checking a coil (p.134)
Setting IE static timing (p.135)
Test bench check (IE) (p.137)
Setting IE static timing with strobe (p.138)
Check oil pressure (p.141)
Check Thermostat (p.142)
Adjusting pulleys and belts (p.143)
Clutch (p.147)
Clutch mechanism (p.148)
Basic adjust. (bvh) (p.51)
Control (hydraulic) (p.153)
Control (Manual) (p.157)
Torque converter (p.161)
Gearbox (p.163)
4-speed (p.163)
Hydraulic gearchange (p.168)
Manual gearchange (p.172)
5-speed (p.174)
Automatic gearbox (p.177)
Drive shafts (p.197)
Hydraulic system (p.200)
Source and reserve of pressure (p.200)
Check hydraulic parts on vehicle (p.206)
Checking sphere pressure (p.212)
Front Axle - data (p.213)
Adjusting camber and toe-in (p.216)
Rear Axle (p.218)
Suspension (p.220)
Height pre-adjustment (p.223)
Adjusting front anti-roll bar (p.227)
Adjusting manual height control (p.228)
Adjust man. ht. control rods (p.226)
Steering (p.230)
Adjusting lateral and angular position of the steering (p.233)
Set toe-in, adjust lock (p.234)
Adjusting crossover pressure (p.235)
Adjust straight-ahead posn (p.a.s.) (p.236)
Brakes (p.239)
All except DV-DT and DP (p.239)
DV, DT, DP (p.240)
All types - data (p.241)
Adjusting brakes (p.243)
Bleeding brakes (p.245)
Brake pedal control (p.247)
Brake control valve (p.249)
Security valve (p.251)
Parking brake adjustment (p.253)
Electricity (p.255)
DX-DJ Sept'65 - Sept'66 (p.255)
Wiring diagram (p.256)
Key to wiring diagram (p.257)
Wiring schedule (p.258)
DY, DL, DE Sept '65- Sept 66 (p.262)
Bulb table (p.262)
Wiring Diagram (p.263)
Key to wiring diagram (p.264)
Wiring schedule (p.265)
DX, DJ, DY, DL Sept '66- Sept '67 RH Battery (p.270)
Key to wiring diagram (p.270)
Wiring diagram (p.271)
Schedule of wiring (p.272)
DV Sept '66- Sept '67 (p.277)
Bulb table (p.277)
Wiring diagram (p.278)
Key to wiring diagram (p.279)
Schedule of wiring (p.280)
DX, DJ, DY, DL Sept - Dec '67 (p.285)
Bulb table (p.285)
Wiring diagram (p.286)
Key to wiring diagram (p.287)
DV Sept '67- Dec '67 (p.294)
Key to wiring diagram (p.294)
Wiring diagram (p.295)
DX, DJ, DY, DL, DV Dec '67- Oct '68 (p.300)
Wiring diagram (p.301)
Changed wiring details (p.302)
DX, DJ Oct '68- Jan '69 (p.303)
Key to wiring diagram (p.303)
Wiring diagram (p.304)
Wiring schedule (p.305)
DY, DL, DV Sept '68- Jan '69 (p.311)
Key to wiring diagram (p.311)
Wiring diagram (p.312)
Wiring schedule (p.313)
DX, DJ Jan '69- Sept '69 (p.319)
Wiring diagram (p.320)
QI auxiliary light wiring (p.321)
DY, DL Jan '69- Sept 69 (p.322)
Wiring changes (p.322)
Wiring diagram (p.324)
Wiring schedule (p.325)
DX, DJ, DY, DT, DV from Sept '69 (p.326)
Bulb table (p.326)
Fuse table (p.327)
Key to wiring diagram (p.328)
Wiring diagram (p.329)
Schedule of wiring. (p.330)
bvm DJ, DV, DT since Apr '71 (p.336)
Bulb table (p.336)
Wiring diagram (p.337)
Fuse table (p.338)
Key to wiring diagram (p.339)
Wiring schedule (p.340)
bvm from Sep '71 (p.346)
Explanation of diagram system (p.347)
Basic diag. LHD (p.348)
Basic diag. RHD (p.349)
Installation diagram LHD (p.350)
Installation diagram RHD (p.351)
Fuse table (p.352)
Bulb table (p.353)
bvh from Sep '71 (p.354)
Explanation of diagram system (p.355)
Basic diag. LHD (p.356)
Basic diag. RHD (p.357)
Installation diagram LHD (p.358)
Installation diagram RHD (p.359)
Bulb table (p.361)
B/W Automatic cars (p.362)
D.IE up to Mar '70 (p.363)
Starter motor control (p.363)
EFI wiring diagram (p.364)
Key to wiring diagram (p.365)
Wiring schedule (p.366)
D.IE Mar '70 - Apr '71 (p.368)
Starter motor control (p.368)
Wiring diagram (p.369)
Key to wiring diagram (p.370)
Wiring schedule (p.371)
DX.IE from April '71 (p.374)
Starter motor control (p.374)
Wiring diagram (p.375)
Key to wiring diagraam (p.376)
Wiring schedule (p.377)
DJ.IE from April '71 (p.380)
Wiring diagram (p.381)
Key to wiring diagram (p.382)
Wiring schedule (p.383)
Air Conditioning (p.386)
Wiring diagrams (p.387)
Description (p.388)
Battery, Generator, Starter (p.389)
Voltage regulator adjustment (p.392)
Starter adjustment (p.395)
Headlamps (p.397)
Levelling from Sept '67 (p.397)
Directional control (p.405)
DX, DJ to Sep '67 (p.415)
Other types to Sep '67 (p.421)
Adjusting fixed lights from Sep 67 (p.422)
Air conditioning (p.424)
Filling the cooling circuit (p.428)
Body (p.431)
Vehicle dimensions (p.431)
Saloon (p.431)
Decapotable (p.432)
Safari de luxe (p.434)
Safari - luxury interior (p.435)
Commercial (p.436)
Ambulance (p.437)
Panel fit (p.438)
Bonnet, front wings and doors (p.438)
Boot lid, rear wings, doors (p.439)
Adjusting doors and locks (p.440)
Adjusting bonnet lock (p.441)
Rear window demister (p.443)
Special tools (p.445)
List of special tools (p.445)
Drawings of tools not sold. (p.447)
REPRESENTATIVE EXCERPT — FOR REFERENCE ONLY (from p.180)
In this case the engagement of the 2nd. gear is not restricted. It can occur at any speed. CAUTION : /n order to avoid excessive speeds, which are harmful to the engine, never perform this operation at a speed higher than 81 mph (130 km/h). . POSITION «1»: Locking of the first gear This position is used for exceptional driving conditions : travelling up or down steep gradients (mountainous
Choose a section…
Title Page (p.1)
Using the manual (p.2)
Factory Type symbols (p.8)
General characteristics (p.10)
Grnd clearance, weight (p.11)
Tyres/rims, dimensions (p.10)
Advice and precautions (p.13)
Electrical precautions (p.13)
LHS2 (p.15)
LHM (p.16)
Hydraulic work - general (p.17)
Draining the fluid (p.21)
Refilling (p.22)
Approved pastes, glues, solvents (p.25)
Engine (p.27)
Data (p.27)
Oil circulation diagram (p.28)
Cross-section drawings (p.29)
Data (IE) (p.36)
Cross-section (IE) (p.37)
Oil circulation (IE) diagram (p.39)
Adjusting valve clearances (p.40)
Adjusting IE valve clearances (p.42)
Adjusting engine mountings (p.44)
Weber carburettor (p.46)
Setting clutch clearance and idle (bvh) (p.51)
Adjusting idle speed (bvm) (p.53)
Adjusting accelerator control (p.54)
Adjusting idle (post Sep '72 (p.55)
Adjusting idle (BW) (p.56)
Adjusting EFI (bvh) (p.57)
Adjusting EFI (bvm) (p.60)
Adjusting EFI (bw) (p.61)
Using Citroen tester (p.62)
Using Bosch tester (p.90)
Fuel pump -EFI (p.116)
Fuel pump - carburettor (p.117)
Ignition (p.119)
Ignition advance curves (p.119)
Set static timing to '71 (p.124)
Set static timing '71-> (p.125)
Set timing w. strobe (p.127)
Test-bench distributor check (p.133)
Checking a coil (p.134)
Setting IE static timing (p.135)
Test bench check (IE) (p.137)
Setting IE static timing with strobe (p.138)
Check oil pressure (p.141)
Check Thermostat (p.142)
Adjusting pulleys and belts (p.143)
Clutch (p.147)
Clutch mechanism (p.148)
Basic adjust. (bvh) (p.51)
Control (hydraulic) (p.153)
Control (Manual) (p.157)
Torque converter (p.161)
Gearbox (p.163)
4-speed (p.163)
Hydraulic gearchange (p.168)
Manual gearchange (p.172)
5-speed (p.174)
Automatic gearbox (p.177)
Drive shafts (p.197)
Hydraulic system (p.200)
Source and reserve of pressure (p.200)
Check hydraulic parts on vehicle (p.206)
Checking sphere pressure (p.212)
Front Axle - data (p.213)
Adjusting camber and toe-in (p.216)
Rear Axle (p.218)
Suspension (p.220)
Height pre-adjustment (p.223)
Adjusting front anti-roll bar (p.227)
Adjusting manual height control (p.228)
Adjust man. ht. control rods (p.226)
Steering (p.230)
Adjusting lateral and angular position of the steering (p.233)
Set toe-in, adjust lock (p.234)
Adjusting crossover pressure (p.235)
Adjust straight-ahead posn (p.a.s.) (p.236)
Brakes (p.239)
All except DV-DT and DP (p.239)
DV, DT, DP (p.240)
All types - data (p.241)
Adjusting brakes (p.243)
Bleeding brakes (p.245)
Brake pedal control (p.247)
Brake control valve (p.249)
Security valve (p.251)
Parking brake adjustment (p.253)
Electricity (p.255)
DX-DJ Sept'65 - Sept'66 (p.255)
Wiring diagram (p.256)
Key to wiring diagram (p.257)
Wiring schedule (p.258)
DY, DL, DE Sept '65- Sept 66 (p.262)
Bulb table (p.262)
Wiring Diagram (p.263)
Key to wiring diagram (p.264)
Wiring schedule (p.265)
DX, DJ, DY, DL Sept '66- Sept '67 RH Battery (p.270)
Key to wiring diagram (p.270)
Wiring diagram (p.271)
Schedule of wiring (p.272)
DV Sept '66- Sept '67 (p.277)
Bulb table (p.277)
Wiring diagram (p.278)
Key to wiring diagram (p.279)
Schedule of wiring (p.280)
DX, DJ, DY, DL Sept - Dec '67 (p.285)
Bulb table (p.285)
Wiring diagram (p.286)
Key to wiring diagram (p.287)
DV Sept '67- Dec '67 (p.294)
Key to wiring diagram (p.294)
Wiring diagram (p.295)
DX, DJ, DY, DL, DV Dec '67- Oct '68 (p.300)
Wiring diagram (p.301)
Changed wiring details (p.302)
DX, DJ Oct '68- Jan '69 (p.303)
Key to wiring diagram (p.303)
Wiring diagram (p.304)
Wiring schedule (p.305)
DY, DL, DV Sept '68- Jan '69 (p.311)
Key to wiring diagram (p.311)
Wiring diagram (p.312)
Wiring schedule (p.313)
DX, DJ Jan '69- Sept '69 (p.319)
Wiring diagram (p.320)
QI auxiliary light wiring (p.321)
DY, DL Jan '69- Sept 69 (p.322)
Wiring changes (p.322)
Wiring diagram (p.324)
Wiring schedule (p.325)
DX, DJ, DY, DT, DV from Sept '69 (p.326)
Bulb table (p.326)
Fuse table (p.327)
Key to wiring diagram (p.328)
Wiring diagram (p.329)
Schedule of wiring. (p.330)
bvm DJ, DV, DT since Apr '71 (p.336)
Bulb table (p.336)
Wiring diagram (p.337)
Fuse table (p.338)
Key to wiring diagram (p.339)
Wiring schedule (p.340)
bvm from Sep '71 (p.346)
Explanation of diagram system (p.347)
Basic diag. LHD (p.348)
Basic diag. RHD (p.349)
Installation diagram LHD (p.350)
Installation diagram RHD (p.351)
Fuse table (p.352)
Bulb table (p.353)
bvh from Sep '71 (p.354)
Explanation of diagram system (p.355)
Basic diag. LHD (p.356)
Basic diag. RHD (p.357)
Installation diagram LHD (p.358)
Installation diagram RHD (p.359)
Bulb table (p.361)
B/W Automatic cars (p.362)
D.IE up to Mar '70 (p.363)
Starter motor control (p.363)
EFI wiring diagram (p.364)
Key to wiring diagram (p.365)
Wiring schedule (p.366)
D.IE Mar '70 - Apr '71 (p.368)
Starter motor control (p.368)
Wiring diagram (p.369)
Key to wiring diagram (p.370)
Wiring schedule (p.371)
DX.IE from April '71 (p.374)
Starter motor control (p.374)
Wiring diagram (p.375)
Key to wiring diagraam (p.376)
Wiring schedule (p.377)
DJ.IE from April '71 (p.380)
Wiring diagram (p.381)
Key to wiring diagram (p.382)
Wiring schedule (p.383)
Air Conditioning (p.386)
Wiring diagrams (p.387)
Description (p.388)
Battery, Generator, Starter (p.389)
Voltage regulator adjustment (p.392)
Starter adjustment (p.395)
Headlamps (p.397)
Levelling from Sept '67 (p.397)
Directional control (p.405)
DX, DJ to Sep '67 (p.415)
Other types to Sep '67 (p.421)
Adjusting fixed lights from Sep 67 (p.422)
Air conditioning (p.424)
Filling the cooling circuit (p.428)
Body (p.431)
Vehicle dimensions (p.431)
Saloon (p.431)
Decapotable (p.432)
Safari de luxe (p.434)
Safari - luxury interior (p.435)
Commercial (p.436)
Ambulance (p.437)
Panel fit (p.438)
Bonnet, front wings and doors (p.438)
Boot lid, rear wings, doors (p.439)
Adjusting doors and locks (p.440)
Adjusting bonnet lock (p.441)
Rear window demister (p.443)
Special tools (p.445)
List of special tools (p.445)
Drawings of tools not sold. (p.447)
